(Kopie 1)

ChipIce factories

 

in containers

 

from 3,500 to 10,000 kg daily capacity

 

The ice factories are built into 20' or 40' containers and are delivered turnkey ready for connection to water and electricity.

Thanks to the reinforced machine design and excellent corrosion protection, our ice factories are ideally suited for installation in tropical climates and in salty sea air.
During operation, you do not need any personnel for machine operation due to the fully automatic and self-monitoring mode of operation. The plant consists of a PVC-coated ISO container equipped as follows:

Machine room:

includes the complete ice machine, cooling unit for the ice store (optionally also with cooling unit to store fresh goods) and the electrical control system. Heat is dissipated from the air-cooled condensers through the rear doors and mesh windows on the side walls. Non-slip floor with checker plate covering. Lighting in the engine room and ice storage available.

 

ZIEGRA ChipIce machine

consisting of 2 redundant production units, each with 50% of the total capacity. If the full capacity is not required, one unit can be switched off without any problems. In addition, the duplicity increases your production reliability, as only one side is affected in the event of a malfunction. This means that a minimum capacity of 50% can always be maintained.

A cooling coil is placed around the freezing cylinder, which freezes the water on its inside. The ice is continuously peeled off the inner wall of the cylinder by the screw in a very thin freezing layer and conveyed upwards. There the ice is pressed hard, refrozen, then broken and then ejected.

Ice storage

The ice produced is conveyed to the ice storage and distributed there by a fan to ensure optimum utilisation of the storage space. Ice storage made of panels with 120 mm PUR insulation. Stainless steel interior, walls and floor are connected watertight. Drainage for melting and cleaning water available. Optionally available are doors to the ice storage, which can be opened from the inside and outside, position of additional doors according to customer requirements. Removable partition behind the door.

The ice storage can also be used as a storage for fresh goods (without subdivision), alternatively for 40' containers with subdivision as storage for fresh goods and for ice. The ice storage is accessible from the outside.

[Translate to English:]

Eismaschine, kompakt & steckerfertig
Leistung / 24h : 30 kg
bei 20°C Luft & 15°C Wasser
Eisspeicher: 10 kg
Gehäuse Edelstahl
Maße: 40x50x71 cm (BxTxH)
Gewicht: 60 kg
Spannung: 230V-1-50Hz (andere möglich)
Kältemittel: R404A

Download PDF

UBE 5.000-2 C20

Chip ice factory in 20 feet CONTAINER
capacity / 24h: 5.000 kg 
with 2 separate aggregates á 50%
at 35°C ambient & 25°C water (others possible)
Integrated ice bunker with cooling unit: approx. 5 t capacity
Voltage: 400V-3-50Hz
Refrigerant: R404A

 

UBE 5.000 C40

Chip ice factory in 40 feet CONTAINER
Capacity / 24h: 5.000 kg
at 35°C ambient & 25°C water (others possible)
Integrated ice bunker with cooling unit: approx. 15 t capacity
Voltage: 400V-3-50Hz*
Refrigerant: R404A

 

UBE 5.000-2 C40

Chip ice factory in 40 feet CONTAINER
Capacity / 24h: 5.000 kg
with 2 separate aggregates á 50%
at 35°C ambient & 25°C water (others possible)
Integrated ice bunker with cooling unit: approx. 15 t capacity
Voltage: 400V-3-50Hz
Refrigerant: R404A

 

UBE 7-500 C20

Chip ice factory in a 20-foot CONTAINER
Capacity / 24h: 7.500 kg
at 35°C ambient & 25°C water (others possible)
Integrated ice bunker with cooling unit: approx. 5 t capacity
Voltage: 400V-3-50Hz*
Refrigerant: R404A

 

UBE 7-500 C40

Chip ice factory in a 40-foot CONTAINER
Capacity / 24h: 7.500 kg
at 35°C ambient & 25°C water (others possible)
IIntegrated ice bunker with cooling unit: approx. 15 t capacity
Voltage: 400V-3-50Hz
Refrigerant: R404A

 

UBE 10.000-2 C20

Chip ice factory in 20 feet CONTAINER
capacity / 24h: 10.000 kg 
with 2 separate aggregates á 50%
at 35°C aimbient & 25°C water (others possible)
Integrated ice bunker with cooling unit: approx.5 t capacity
Voltage: 400V-3-50Hz*
Refrigerant: R404A

 

UBE 10.000-2 C40

Chip ice factory in the foot 40 CONTAINER
capacity / 24h: 10.000 kg
with 2 separate aggregates á 50%
at 35°C ambient & 25°C water (others possible)
Integrated ice bunker with cooling unit: approx. 15 t capacity
Voltage: 400V-3-50Hz
Refrigerant: R404A

 


Sie haben Fragen ? - senden Sie uns eine Anfrage

Wir nutzen Ihre Kontaktdaten rein im Zuge Ihrer Anfrage

Contact

Ziegra Ice Machines Ltd
Sattlerstr. 5
D-30916 Isernhagen

Phone:  +49 (0)511 90 244 0
Telefax: +49 (0)511 90 244 90

ice(at)ziegra.com
www.ziegra.com

Downloads

Catalogues

Data Sheets

Certificates

 

Sustainability

Cooling should be refreshing, gentle, soothing, caring whether on products, in processes or on people. Our world needs to be treated with care – which is best achieved using natural and environmentally-friendly methods but without compromising performance. Exactly how Ice is made when produced by machines from the new ZIEGRA CoolNat series.

 

 

go-digital Förderung

Digitalisation, supported by the go-digital funding programme
Consulting, planning, implementation by Kamann & Partner

 

Legal information

AGB

Payment and shipping

Contact

Imprint

Privacy

Social Bookmarking

© ZIEGRA Eismaschinen GmbH 2020